博世力士樂Rexroth軸向柱塞泵當力士樂葉片泵在機械上使用時，這時我們是需要安裝的，安裝完之后我們就得檢查好是否完整，然后就開始啟動了，說到啟動也是需要注意的，如果我們不按程序來啟動，那么就會容易出現問題，為了避免這樣的問題出現，下面就由澳托士的技術員給大家講一講力士樂葉片泵啟動程序方法如下：一、在加注液壓油之前保證油箱和回路清潔，沒有泥土和碎屑。
二、用經過過濾的油液加注油箱并加注到足以防止在通泵進油口的吸油連接處產生旋渦的液面，用外部的輔助泵通過沖洗和過濾來凈化系統是良好的做法。
三、力士樂葉片泵起動之前，經一個油口灌注油液。
如果泵高于油箱油面，則這一點特別重要。
四、力士樂葉片泵初次起動時，從系統中清除滯留空氣。
在起動前松開泵出油口管接頭或利用放氣閥即可實現放氣。
所有進油口連接必須嚴格防止漏氣。
五、力士樂葉片泵一經起動，泵灌滿之后，旋緊松開的出油口接頭，然后無載運行5至10min以便從回路中清除所有的滯留空氣。
六、如果油箱有可視液位計，要保證油液清澈，不得乳化。
向油箱填加油液，使之能達到正確的注油液位。

博世力士樂Rexroth軸向柱塞泵了解并很熟悉力士樂葉片泵的用戶們，應該都清楚，我們?cè)诟簤合到y(tǒng)接觸的過程中，有很多細節的操作可能影響著力士樂葉片泵的使用壽命，影響士樂葉片泵的使用壽命因素很多，除了泵自身設計、制造因素外和一些與泵使用相關元（如聯軸器、濾油器等）的選用、試車運行過程中的操作等也有關的，那么力士樂葉片泵影響液壓泵使用壽命具體內外因素是什么呢？下面澳托士的技術員就給大家說一說力士樂葉片泵分析影響液壓泵使用壽命的內外因素如下：一、相關元件的分析1)聯軸器的選用①液壓泵傳動軸不能承受徑向力和軸向力，因此不允許在軸端直接安裝帶輪、齒輪、鏈輪，通常用聯軸器聯接驅動軸和泵傳動軸。
如因制造原因，士樂葉片泵與聯軸器同軸度超標，裝配時又存在偏差，則隨著泵的轉速提高離心力加大聯軸器變形，變形大又使離心力加大，造成惡性循環，其結果產生振動噪聲，從而影響泵的使用壽命。
此外，還有如聯軸器柱銷松動未及時緊固、橡膠圈磨損未及時更換等影響因素。
2)聯軸器的裝配要求①剛性聯軸器兩軸的同軸度誤差≤0.05mm；②彈性聯軸器兩軸的同軸度誤差≤0.1mm；③兩軸的角度誤差＜1°；④驅動軸與泵端應保持5～10mm距離。

PV7-1X/17-30REO1MCO-08
PV7-1X/06-10RA01MA0-10
PV7-1X/10-20RE01MC0-10
PV7-1X/10-20RE01MC0-10
PV7-17/16-20RE01MCO-16
PV7-1X/10-20RE01MC0-10
PV7-17/16-20RE01MCO-16
PV7-17/10-20RE01MCO-10
PV7-17/16-20REO1MCO-16
PV7-17/10-20RE01MCO-10
PV7-11/06-10RA01MA0-05
PVV4-1X/098RA15RMC
PVV1-1X/027RA15DVB  R900952287
PV7-17/10-14RE01MC0-16
PV7-17/16-30RE01MCO-08
PV7-17/25-45RE01MCO-08
PV7-17/10-20RE01MCO-10
PVV2-1X/068RA15DMB
PVV1-1X/027RA15DMB
PV7-16/25-30-RE01MC0-16
PV7-1X/100－118REO7MDO-16
PVV1－1X/036RA15DMB
PVV4-1X/122RA15dmc
PV7-1X/63-71RE07MV0-14A1
PV7-1X/63-71RE07MV0-14A1
PVV4-1X/098RAE5DMC
PVV2-1X-040RA15DMB  yongPVV2-1X-068RA15DMB 改泵芯
PVV4-1X/098RA15UMC
PV7-17/16-20RE01MCO-16
PVH131R13AG30A250000001001AB010A
PVPC-L-3029/1D
PVH098QIC-RSM-1S-10-C25-31
PVXS-180-M-R-R-DF-0000
PVB15-RS41-C11
PV7-1X/40-45RE37MC0-16

此葉片的主要特點是很短的控制時間,運行噪音低.裝配和連接尺寸符合VADA24560/1SO3019/2,效率高,壽命長,可變排量

力士樂rexroth葉片泵
PV7-17/10-20RE01MCO-10
PV7-17/10-14RE01MCO-16
R901292147 PV7-1X/10-20RE01MCO-10-A497
PV7-11/06-10RA01MA0-05
PV7-1X/16-20RE01MC0-16
PV7-1A/16-30RE01MCO-08
PV7-2X/20-25 RA01MA0-10
PV7-11/06-10RA01MA0-10 印度產
PV7-17/10-14RE01MCO-16
PV7-11/06-10RA01MA0-10
PV7-17/10-14RE01C0-16
PV7-17/10-20REO1MC0-08
PV7-17/10-20REO1MC0-08
PV7-20/20-25RA01MA0-05
PV7-18/63-71RE07MC0-16
PV7-19/40-71RE37MC0-08
PV7-19/40-71RE37MC0-08
R900506808 PV7-18/63-71RE07MC0-16
R900950954 PV7-2X/20-25RA01MA0-05
PV7-2X/20-25RA01MA0-05印度產

型號
PV7-17/10-14RE01MCO-16
PV7-17/10-14RE01MCO-16
PV7-2X/20-20RA01MA0-10
PV7-17/16-30REOMCO-08
PV7-20/20-25RA01MAO-10
PV7-1X/16-20
PV7-1X/63-94
PV7-1X/16-20
PV7-1X/63-94
PV7-1X/16-20
PV7-1X/63-94
PV7-1X/06-10RA01MA0-10
PV7-16/16-30RE01MCO-08
PV7-1X/40-45RE37MCO-16
PV7-17/10-20RE01MCO-10
PV7-1X/25-30RE10/MCO-16
PV7-17/10-20RE01MCO-10 RV 250/
PV7-17/10-20RE01MCO-10 RV 250/
PV7-1X/06-10RA01MAC-10
PV7-17/16-20REO1MCO-16

R900701362 PV7-1X/40-45RE37KD0-16
R900700384 PV7-1X/40-45RE37MW0-16WH
R900598753 PV7-1X/10-14RE01MC3-16
R900593330 PV7-1X/40-45RE37MD0-16
R900592237 PV7-1X/16-20RE01MC3-16
R900590087 PV7-1X/40-45RE37MC3-16
R900586235 PV7-1X/25-30RE01MC3-16
R900580384 PV7-1X/40-45RE37MC0-16
R900580383 PV7-1X/25-30RE01MC0-16
R900580382 PV7-1X/16-20RE01MC0-16
R900580381 PV7-1X/10-14RE01MC0-16
R900576487 PV7-1X/25-45RE01MC5-08WH
R900574560 PV7-1X/63-94RE07MD0-08
R900573212 PV7-1X/16-20RE01MD0-16-A234
R900571305 PV7-1X/63-71RE07KC0-16
R900568873 PV7-1X/100-150RE07KC0-08
R900568833 PV7-1X/25-45RE01MD0-08
R900564746 PV7-1X/06-10RA01MA3-10
R900563233 PV7-1X/06-10RA01MA0-10
R900562475 PV7-1X/25-30RE01KC0-16
R900561857 PV7-1X/06-10RA01MA0-05
R900561846 PV7-1X/100-150RE07MC0-08
R900561581 PV7-1X/40-71RE37MC3-08
R900560916 PV7-1X/10-14RE01KC0-16
R900560659 PV7-1X/63-94RE07MC0-08
R900560658 PV7-1X/16-30RE01MD0-08
R900560629 PV7-1X/100-150RE07MC5-08
R900556803 PV7-1X/100-118RE07MC5-16WH
R900553692 PV7-1X/63-71RE07MC5-16WG
R900553588 PV7-1X/40-45RE37MC5-16WH
R900551273 PV7-1X/25-45RE01MC7-08
R900551051 ABHAG-0160S43/PV7-16-30/112M/S /S02G781A
R900548512 PV7-1X/10-14RE01MD0-16-A234
R900546887 PV7-1X/63-71RE07KC3-16
R900546886 PV7-1X/25-30RE01KC3-16
R900539886 PV7-1X/40-71RE37MD0-08
R900538525 PV7-1X/25-45RE01MC3-08
R900538125 PV7-1X/10-20RE01MC3-10
R900537419 PV7-1X/10-14RE01MN0-16
R900534508 PV7-1X/25-45RE01MC0-08
R900534412 PV7-1X/16-20RE01MC7-16
R900534143 PV7-1X/10-20RE01MC0-10
R900533851 PV7-1X/10-14RE01MC0-16-A184
R900533637 PV7-1X/100-118RE07MC7-16
R900533582 PV7-1X/16-30RE01MC0-08
R900533296 PV7-1X/16-30RE01MC3-08
R900532770 PV7-1X/100-118RE07MD0-16
R900535588 PV7-1X/40-71RE37MC0-08
R900535532 PV7-1X/25-45RE01MC5-08
R900523597 PV7-1X/40-45RE37KC0-16
R900520787 PV7-1X/10-14RE01MD5-16
R900520401 PV7-1X/10-14RE01MC5-16
R900519094 PV7-1X/63-71RE07MD0-16
R900518218 PV7-1X/63-71RE07MC5-16
R900517795 PV7-1X/16-20RE01MC0-16-A184
R900517464 PV7-1X/25-30RE01MC5-16
R900516546 PV7-1X/100-118RE07MC5-16
R900511986 PV7-1X/63-71RE07MC3-16
R900511215 PV7-1X/100-118RE07MC3-16
R900509506 PV7-1X/25-30RE01MD0-16
R900509274 PV7-1X/16-20RE01MD0-16
R900509053 PV7-1X/10-14RE01MC7-16
R900506809 PV7-1X/100-118RE07MC0-16
R900506808 PV7-1X/63-71RE07MC0-16
R900506473 PV7-1X/16-20RE01MC5-16
R900504653 PV7-1X/10-14RE01MD0-16
R900502277 PV7-1X/40-45RE37MC5-16
R901134661 PV7-1X/16-20RE01MD6-16
R901133981 PV7-1X/63-71RE07MC3-06-A460
R901129340 PV7-1X/100-118RE07MW6-16WH
R901081778 PV7-1X/06-14RA01MA0-10-A452
R901065655 PV7-1X/06-10RA01KA0-05
R901064326 PV7-1X/40-55RE37MC0-08-A449
R901061279 PV7-1X/100-118RE07MW0-16WG
R901059512 PV7-1X/40-71RE37MW0-08WH
R901055473 PV7-1X/40-45RE37MW0-16WG
R901049299 ABAPG-PV7-118D0+10SO18DRG/225S-4-B0/SEFR
R901047776 PV7-1X/40-45RE37MC0-16-A446
R901047606 PV7-1X/06-10RA01KA0-10
R901043560 PV7-1X/10-20RE01MW0-10WH
R901032005 PV7-1X/40-45RE37MC7-16WG
R901026649 PV7-1X/06-10RA01MA0-10-A441
R901022287 PV7-1X/25-30RE01MN0-16
R901021722 PV7-1X/63-71RE07KW0-16WG
R901017159 PV7-1X/63-71RE07MW0-16WH
R900979440 PV7-1X/40-45RE37MW0-16
R900978121 PV7-1X/06-10RE01MA3-10
R900976176 PV7-1X/25-45RE01MN0-08
R900976100 PV7-1X/63-71RE07MC6-16
R900973308 PV7-1X/06-14RA01MA0-07-A399
R900973306 PV7-1X/06-14RA01MA0-04-A399
R900964375 PV7-1X/06-14RE01MA3-07
R900963916 PV7-1X/06-10RA01MA0-10-A501
R900961521 PV7-1X/100-118RE07MC6-16
R900959317 PV7-1X/40-45RE37MC7-16
R900958306 PV7-1X/06-14RE01MA0-07
R900954137 PV7-1X/40-45RE37MC6-16
R900952282 PV7-1X/06-14RA01MA3-07
R900950419 PV7-1X/100-118RE07MD0-16-A234
R900950061 PV7-1X/100-118RE07MC5-16WG
R900949187 PV7-1X/100-118RE07MD6-16
R900948299 PV7-1X/100-150RE07MC5-08WH
R900946174 PV7-1X/40-45RE37MC0-16-A276
R900942455 PV7-1X/63-71RE07MC5-16WH
R900941073 PV7-1X/10-14RE01MC0-16-A268
R900941071 PV7-1X/10-14RE01MC0-16-A267
R900939159 PV7-1X/16-20RE01MN0-16
R900937407 PV7-1X/100-150RE07KD0-08
R900936326 PV7-1X/06-10RE01MA0-05
R900935443 PV7-1X/40-45RE37MC3-16-A184
R900933324 PV7-1X/10-14RE01MC5-16WH
R900933323 PV7-1X/25-30RE01MC5-16WH
R900931321 PV7-1X/06-14RA01MA0-04-A257
R900930060 PV7-1X/10-14RE01MC0-16-A202
R900928704 PV7-1X/100-118RE07MN0-16
R900926429 PV7-1X/16-20RE01MC5-16 WH
R900925956 PV7-1X/63-71RE07MD0-16-A234
R900922602 PV7-1X/40-45RE37MD0-16-A234
R900920233 PV7-1X/16-20RE01MC0-16-A17
R900919237 PV7-1X/06-14RA01MA0-07
R900919235 PV7-1X/06-14RA01MA0-04
R900916201 PV7-1X/10-20RE01KC0-10
R900915470 PV7-1X/100-150RE07MD0-08
R900910480 PV7-1X/63-71RE07MD5-16
R900910479 PV7-1X/100-150RE07MD5-08
R900910016 PV7-1X/40-45RE37MC5-16WG
R900906584 PV7-1X/10-20RE01MD0-10
R900903108 PV7-1X/06-10RE01MA0-10